Listed below are the Sections of the Current ECUA Engineering Manual, approved on December 18, 2014 along with Update #1 dated 9/1/16. General questions about the Manual can be e-mailed to ecuaeng.contact@ecua.fl.gov. Project specific questions related to the Manual's contents should be directed to the ECUA Engineer, Inspector, and/or Engineer-of-Record of that project.
ATTENTION
ECUA issued Update #1 to the Engineering Manual on September 1, 2016. Capital Improvement Projects, System Extensions, and Single Service Connections shall utilize the appropriate Manual per the following:
Projects submitted to ECUA... | Shall use Manual... |
...prior to September 1, 2016 | December 18, 2014 Edition |
...on or after September 1, 2016 | Septmber 1, 2016 Update #1 |
Per below, files for both the December 18, 2014 Manual and September 1, 2016 Update #1 are available. Click Here to view the "Summary of Revisions for Update #1"
Please click here for a full printable PDF version (Divisions 1-5) of the current ECUA Engineering Manual. Please remember to print two-sided.
Division 1- Procedures |
12/18/14 Edition |
Update #1 9/1/16 |
|
Procedure 1 | Engineering Manual Users Guide | ||
Procedure 2 | Review and Approval of Water/Sewer System Extensions | PDF |
PDF |
Procedure 3 | Review and Approval of Single Service Connections | ||
Procedure 4 | Contract Administration for CIP Projects | PDF |
|
Procedure 5 | Septic Tank Abatement Policy | PDF |
|
Procedure 6 | Oversizing | PDF |
|
Procedure 7 | Review and Approval of Grinder Pump Reimbursement Requests | PDF |
|
Procedure 8 | New Product Review and Approval | PDF |
|
Procedure 9 | Property Acquistion and Easements | PDF |
|
Procedure 10 | Miscellaneous Information | PDF |
Division 2- Design Standards |
12/18/14 Edition |
Update #1 9/1/16 |
|
Section 101 | Plan Preparation | ||
Section 556 | Water Distribution Systems | ||
Section 570 | Gravity Sewer Collection Systems | ||
Section 575 | Wastewater Lift Stations | ||
Section 576 | Wastewater Force Main Systems | ||
DS-0.1 & 0.2 | Lift Stations Design Standard Drawings Instructions | N/A | |
DS-1 | Title Sheet | N/A | PDF DWG |
DS-2 | Site Plans | N/A | PDF DWG |
DS-3.1 | Wet Well, Pumps, Piping | N/A | PDF DWG |
DS-3.2 | Wet Well, Pumps, Piping with Flow Meter | N/A | PDF DWG |
DS-4 | Site-Civil-Mechanical Details 1 | N/A | PDF DWG |
DS-5 | Site-Civil-Mechanical Details 2 | N/A | PDF DWG |
DS-6 | Site-Civil-Mechanical Details 3 | N/A | PDF DWG |
DS-7 | Site-Civil-Mechanical Details 4 | N/A | PDF DWG |
DS-8 | D.E.D Performance Design Criteria | N/A | PDF DWG |
DS-9 | D.E.D Title Sheet | N/A | PDF DWG |
DS-10 | Electrical Symbols and Abbreviations | N/A | PDF DWG |
DS-11 | Single Line Diagram Options | N/A | PDF DWG |
DS-12.1 | PDS - Sheet 1 (incl. Power Feeder Circuit Option 1) | N/A | PDF DWG |
DS-12.2 | Power Feeder Circuit Options 2-5 | N/A | PDF DWG |
DS-13 | PDS - Sheet 2 | N/A | PDF DWG |
DS-14.1 | Power Panel - Equipment Lists and Notes | N/A | PDF DWG |
DS-14.2 | Power Panel - HP Related Components Equipment Lists | N/A | PDF DWG |
DS-15 | Power Panel - Terminal Block Layout | N/A | PDF DWG |
DS-16 | Power Panel - Interior Layout | N/A | PDF DWG |
DS-17 | Power Panel - Misc. Bracket Details | N/A | PDF DWG |
DS-18.1.1 | Pump 1 Panel - MSS - FVNR | N/A | PDF DWG |
DS-18.1.2 | Pump 1 Panel - MSS - RVSS | N/A | PDF DWG |
DS-18.1.3 | Pump 1 Panel - MSS - VFD | N/A | PDF DWG |
DS-18.2.1 | Pump 2 Panel - MSS - FVNR | N/A | PDF DWG |
DS-18.2.2 | Pump 2 Panel - MSS - RVSS | N/A | PDF DWG |
DS-18.2.3 | Pump 2 Panel - MSS - VFD | N/A | PDF DWG |
DS-19.1.1 | Pump 1 Panel - Interior Layout - FVNR | N/A | PDF DWG |
DS-19.1.2 | Pump 1 Panel - Interior Layout - RVSS | N/A | PDF DWG |
DS-19.1.3 | Pump 1 Panel - Interior Layout - VFD | N/A | PDF DWG |
DS-19.2.1 | Pump 2 Panel - Interior Layout - FVNR | N/A | PDF DWG |
DS-19.2.2 | Pump 2 Panel - Interior Layout - RVSS | N/A | PDF DWG |
DS-19.2.3 | Pump 2 Panel - Interior Layout - VFD | N/A | PDF DWG |
DS-20.1 | Pump Panels - Equipment Lists,Notes - FVNR | N/A | PDF DWG |
DS-20.2 | Pump Panels - Equipment List, Notes - RVSS | N/A | PDF DWG |
DS-20.3 | Pump Panels - Equipment List, Notes - VFD | N/A | PDF DWG |
DS-21 | Pump Panels - Pump Protection Circuits | N/A | PDF DWG |
DS-22 | Control Panel - Schematic | N/A | PDF DWG |
DS-23 | Control Panel - Digital Inputs Schematic | N/A | PDF DWG |
DS-24 | Control Panel - Digital Inputs and Outputs Schematic | N/A | PDF DWG |
DS-25 | Control Panel - Analog Inputs and Outputs Schematic | N/A | PDF DWG |
DS-26.1 | Control Panel - Motor Control - FVNR-RVSS | N/A | PDF DWG |
DS-26.2 | Control Panel - Motor Control - VFD | N/A | PDF DWG |
DS-27 | Control Panel - Interior Layout and Terminal Block | N/A | PDF DWG |
DS-28 | Control Panel - Exterior Layout | N/A | PDF DWG |
DS-29 | Control Panel - Equipment List and Schedules | N/A | PDF DWG |
DS-30 | Control Panel - Intricsic Safe Relay Instructions | N/A | PDF DWG |
DS-31 | Control Panel - Panel to Panel Wiring | N/A | PDF DWG |
DS-31.1 | Control Panel - Panel to Panel Wiring Distribution | N/A | PDF DWG |
DS-32.1 | Panel Enclosures - Layout, Frame - Linear, FVNR, RVSS | N/A | PDF DWG |
DS-32.2 | Panel Enclosures - Layout, Frame - Linear, VFD, AC | N/A | PDF DWG |
DS-32.3 | Panel Enclosures - Layout, Frame - Abutting, FVNR, RVSS | N/A | PDF DWG |
DS-32.4 | Panel Enclosures - Layout, Frane - Abutting, VFD, AC | N/A | PDF DWG |
DS-33.1 | HP Related Equipment and Conductors - 208V - 240V | N/A | PDF DWG |
DS-33.2 | HP Related Equipment and Conductors - 480V | N/A | PDF DWG |
DS-34 | Legends and Tags | N/A | PDF DWG |
DS-35 | Control Panel General Notes | N/A | PDF DWG |
MISC1 | Pump Mounting Baseplate Design | N/A | PDF DWG |
Division 3- Technical Specifications |
12/18/14 Edition |
Update #1 9/1/16 |
|
Section 1000 | Miscellaneous Project Support | ||
Section 1900 | Building Demolition | N/A | |
Section 2000 | Clearing and Grubbing/Grassing/Sodding | ||
Section 2100 | Earthwork | ||
Section 2221 | Trench Excavation, Backfill & Compaction | ||
Section 2300 | Horizontal Directional Drilling | ||
Section 2310 | Jack and Bore | ||
Section 2320 | Cured-in-Place Pipe Lining (CIPPL) | ||
Section 2330 | Cured-in-Place Lateral Lining (CIPPL) | ||
Section 2340 | Pipe Bursting | ||
Section 2350 | Test and Seal | ||
Section 2556 | Water Distribution Systems | ||
Section 2570 | Gravity Sewer Collection Systems | ||
Section 2573 | Manhole Coatings and Rehabilitation | N/A | |
Section 2575 | Wastewater Lift Stations | ||
Section 2576 | Wastewater Force Main Systems | ||
Section 2577 | Fiberglass Wet Wells | ||
Section 2578 | Wet Well Coatings and Rehabilitation | N/A | |
Section 2651 | Television Inspection | ||
Section 2830 | Fencing | ||
Section 3200 | Cast-In-Place Concrete | N/A | |
Section 3300 | Paving for Driveways and Parking Areas | ||
Section 4000 | Record Drawings | ||
Section 16010 | Basic Electrical Requirements | ||
Section 16050 | Basic Electrical Materials and Methods | ||
Section 16055 | Overcurrent Protective Device Coordination | ||
Section 16060 | Grounding and Bonding | ||
Section 16073 | Hangers and Supports for Electrical Systems | ||
Section 16075 | Electrical Identification | ||
Section 16120 | Conductors and Cables | ||
Section 16130 | Raceways and Boxes | ||
Section 16211 | Electricity Metering | ||
Section 16410 | Enclosed Circuit Breakers | ||
Section 16521 | Exterior Lighting | ||
Section 16900 | Systems Integration | ||
Section 16910 | Control Panel Construction | ||
Section 16950 | Field Instruments |
Division 4 - Construction Details |
12/18/14 Edition |
Update#1 9/1/16 |
|
D-1 | Sewer Lateral Connection | ||
D-2 | New Cleanout Installation on Existing Lateral | ||
D-3 | Lateral Connection to CIPP- Lined Pipe | ||
D-10 | Standard Manhole | ||
D-11 | Manhole Frame and Cover | ||
D-12 | Shallow Manhole | ||
D-13 | Drop Manhole | ||
D-14 | Sanitary Sewer Grade Tolerance-Acceptable SAG Limits | N/A | |
D-19 | Manhole Adjustment | ||
D-20 | Low Pressure Residential Sewer Service | ||
D-21 | Force Main Connection to Manhole | ||
D-22 | Low Pressure Flushing Connections | ||
D-23 | Sewer Check Valve Vault | ||
D-30 | Air Release Valve- Manual | ||
D-31 | Air Release/Vacuum Valve- Automatic for 10" and Smaller Mains | ||
D-32 |
Air Release/Vacuum Valve- Automatic for 12" and Larger Mains |
||
D-40 | Water Service for 5/8", 1", and 1 1/2" Meters | ||
D-41 | Typical Chlorine Disinfection | ||
D-42 | Chlorine and Calcium Hypochlorite Required for Disinfection | ||
D-43 | Typical Valve and Box Installation | ||
D-44 | 2", 3", and 4" Meter Vault | ||
D-45 | 6", 8", and 10" Meter Vault | ||
D-46 | Existing Water Main Shutdown Best Management Practices | ||
D-47 | Typical Multiple Water Service Installation | ||
D-48 | Multiple Water Service Installation | N/A | |
D-50 | Typical Fire Hydrant Installation | ||
D-51 | Typical 2" Flush Hydrant | ||
D-52 | Typical Thrust Block Installation | ||
D-59 | Valve Box Adjustment | ||
D-60 | Pipe Envelope Requirements | ||
D-61 | Flexible Pipe Bedding | ||
D-62 | Pipe Joint Restraint Tabulation | ||
D-63 | Pipe Joint Restraint Reducers and Reducing Tees | ||
D-64 | Water/Sewer Separation | ||
D-65 | Typical Jack and Bore | ||
D-66 | Storm Sewer Vertical Separation | ||
D-67 | Pig/Swab Launch Pit | N/A | |
D-68 | Exposed Piping-Equipment Master Color Chart | N/A | |
D-70 | Regional Services Map and Personnel | N/A | |
D-100 | D-100- Lift Station Drawings | N/A | |
D-100+ | D-100+ 240-208V 3-phase 1HP- 15HP FVNR Panel Design | N/A | |
D-100+ | D-100+ 240-208V 3-phase 1HP- 15HP FVNR Panel Design-Alternate | N/A | |
D-100+ | D-100+ 240- 208V 3-phase 1HP- 20HP VFD Electrical Standard | N/A | |
D-100+ | D-100+ 240- 208V 3-phase 1HP- 20HP VFD Electrical Standard- Alternate | N/A | |
D-100+ | D-100+ 240- 208V 3-phase 20HP- 25HP RVSS Electrical Standard | N/A | |
D-100+ | D-100+ 240- 208V 3-phase 20HP- 25HP RVSS Electrical Standard- Alt | N/A | |
D-100+ | D-100+ 480V 3-phase 1HP- 15HP FVNR Electrical Standard | N/A | |
D-100+ | D-100+ 480V 3-phase 1HP- 15HP FVNR Electrical Standard- Alternate | N/A | |
D-100+ | D-100+ 480V 3-phase 1HP- 60HP VFD Electrical Standard | N/A | |
D-100+ | D-100+ 480V 3-phase 1HP- 60HP VFD Electrical Standard- Alternate | N/A | |
D-100+ | D-100+ 480V 3-phase 20HP- 60HP RVSS Electrical Standard ( | N/A | |
D-100+ | D-100+ 480V 3-phase 20HP- 60HP RVSS Electrical Standard- Alternate | N/A |
Division 5 - Forms |
12/18/14 Edition |
Update # 9/1/16 |
Agreement for Residential or Commercial Grinder Pump Station | ||
Application for Reimbursement for Grinder Pump Station | ||
Certification of Completion Form- Sewer | ||
Certification of Completion Form- Water | ||
Change Order Form | ||
ECUA Engineering Manual Reference Note | ||
Fire Hydrant Flow Data Form | ||
Pay Request Form | ||
Pipe Material Summary Chart | ||
ECUA Version of FDOT Utility Permit Special Instructions | ||
Lift Station Design Worksheet | N/A | |
Lift Station Milestone Sign-off Sheet | ||
Lift Station Manufacturers and Sales Contacts | ||
Lift Station Pump Overview Chart | ||
Lift Station Pump Selection Worksheet | ||
Notice of Intent (NOI) Permit | ||
Notification of Commencement of Construction | ||
Capacity Reservation Form | ||
Request for Single Service Connection | ||
Review of Privately-Owned Lift Station | ||
Certification of Developer | ||
System Extensions- Project Information Form | ||
Temporary Construction Easement | ||
Utility Service Agreement | ||
Water Meter Vault Access Agreement |
Division 6 - Supporting Documents |
|
|
Septic Tank Abatement Policy Documents | ||
ECUA Assumption of FDEP Permitting Authority | ||
FDEP Low Pressure Sanitary Sewer Guidelines |